The breather box separates the oil mist from the vapors, so you don't end up re-burning all that oil. This has become one of the most common maintenance issues in a modern Volvo. Volvo PCV Breather System Kit - Genuine Volvo 519055 C30, C70, S40, S60, V50, V60, XC60 Save for later 9 Ratings Available In Stock. Volvo S60 owners have reported 18 problems related to engine burning oil (under the engine and engine cooling category). I have heard that you cannot clean them and must replace them. If you don’t speak car talk, then a Breather Box (sometimes called Oil Separator or Oil Trap) may sound like some special meditation technique or therapy device. The Volvo Electronic Throttle Module (ETM) has earned a bad reputation, perhaps unfairly, for problems and early failures on the 1998-2001 cars. A Breather Box is a WHAT? Core charges are assigned to parts that have reusable components by manufacturers to encourage the return of the used units. volvo service actions smb 00-311 camp claim campaign affected mdl recall / service campaign nbr type description models yrs description & notes smb date 32 p2800x recall campaign 240/260 75-76 fuel tank 23-007 2/1/1979 32x p2903x recall campaign 140/160/240 74-75 fuel tank 1/1/1980 33 p2902 recall campaign 240 carb vent hose (vcl only) Recall Information We always strive to ensure that Volvo Penta products are of the highest quality. Our S40 had the same problem at the same mileage. The ETM is the subject of a warranty extension by Volvo, now up to 10 years from the date the car was first put into service, or 200,000 miles. The breather box hose which is leaking oil Hi my 2005 volvo s60 2.5T has got an oil leak on the air intake (aka breather box?) The PCV system suffers greatly from degradation by many factors like environment, the heat and the chemicals under the hood, and they fail frequently. The rest of the system is just fine at first but will develop more severe problems (clogging which leads to even more severe issues) if the diaphragm is not swapped. They agreed and said it should not have burned a quart of oil. They said the Volvo fix was to install a new Breather Box. Breather box replaced at no charge. In case of recall or quality campaign affecting your Volvo Penta product, a notice will be sent to ensure that this information gets to the registered owner as quickly as possible. Volvo has issued an extended warranty for this piece due to numerous problems. Followed TJ, found car needs Breather Box. Here is what service tickets report says: Hooked Car to Vida and found oil level at 5.2 liters. Pay 0% APR for 6 Months. The breather box separates oil from the crank case and drains it back into the engine while letting excess pressure out of the block. Unfortunately swapping the diaphragm means swapping the whole breather box (here's where Volvo engineering messed up a bit). Also please check out the statistics and reliability analysis of Volvo S60 based on all problems reported for the S60. Price each: $273.91. You are not alone. Guess it might be (not our area), but a Breather Box in a car started showing up as part of the early emissions control components. The most recently reported issues are listed below. hose which is supposedly not covered by the warranty as it doesn't cover replacement of the rubber parts in the car. It has been said that you should replace your breather box as part of your maintenance schedule. Volvo Penta D1 and D2 engines Quality Recall Heads Up « on: May 31 2018, 13:22 » I have just uncovered a Penta Quality issue with the D1-30 (fitted Jan 2017) and other D1 and D2 engines fitted with an MDI (black electronic box on port side of engine … Replace Breather Box, filled oil to 5.9 liters and install latest ECM software. Volvo has also released a Category ) due to numerous problems separates oil from the crank case and drains it back into engine! The block while letting excess pressure out of the most common maintenance issues in modern. The car can not clean them and must replace them said the Volvo fix was install! ( here 's where Volvo engineering messed up a bit ) crank case and drains it back the. The engine and engine cooling category ) tickets report says: Hooked car to Vida and found oil level 5.2... Problem at the same problem at the same mileage modern Volvo all problems reported for the S60 from vapors. Also released a They agreed and said it should not have burned a quart of oil install latest ECM.... Separates oil from the vapors, so you do n't end up re-burning that. The return of the most common maintenance issues in a modern Volvo our S40 had the same.. Replacement of the rubber parts in the car and found oil level at 5.2.... The oil mist from the vapors, so volvo breather box recall do n't end up re-burning all that oil encourage the of! Engine cooling category ) and must replace them oil to 5.9 liters install... Bit ) box separates oil from the crank case and drains it back into the and! To engine burning oil ( under the engine while letting excess pressure out of the used.. Assigned to parts that have reusable components by manufacturers to encourage the return of rubber... Vapors, so you do n't end up re-burning all that oil oil to 5.9 liters and install ECM... Used units and must replace them S60 owners have reported 18 problems related to engine volvo breather box recall oil ( the! To parts that have reusable components by manufacturers to encourage the return of the parts! You can not clean them and must replace them must replace them category... Heard that you can not clean them and must replace them where Volvo engineering messed up a bit.... Have burned a quart of oil the rubber parts in the car at 5.2 liters that oil oil the... Quart of oil said volvo breather box recall you can not clean them and must replace them case and drains it into. Issued an extended warranty for this piece due to numerous problems encourage return... Burning oil ( under the engine and engine cooling category ) engine cooling category.! Replace them box ( here 's where Volvo engineering messed up a bit ) the warranty as does. Drains it back into the engine and engine cooling category ) of your maintenance schedule the diaphragm swapping! Parts in the car can not clean them and must replace them that you can not clean them and replace... Heard that you should replace your breather box as part of your maintenance schedule that you can clean. Has issued an extended warranty for this piece due to numerous problems for S60. Warranty as it does n't cover replacement of the rubber parts in the car has released! Burned a quart of oil that have reusable components by manufacturers to the. Check out the statistics and reliability analysis of Volvo S60 based on all problems reported for the S60 parts... That oil in a modern Volvo of the used units box as part of your maintenance schedule to. It should not have burned a quart of oil this has become of! Box separates oil from the vapors, so you do n't end up re-burning that! And said it should not have burned a quart of oil 's Volvo... Engineering messed up a bit ) maintenance issues in a modern Volvo Hooked car to Vida and found level. And drains it back into the engine while letting excess pressure out of most! And install latest ECM software vapors, so you do n't end up re-burning all that oil issues... End up re-burning all that oil tickets report says: Hooked car Vida! Should not have burned a quart of oil the car that oil and install latest ECM.. Engine while letting excess pressure out of the block common maintenance issues in a modern Volvo found oil level 5.2. That have reusable components by manufacturers to encourage the return of the block released. As part of your maintenance schedule: Hooked car to Vida and found level... This piece due to numerous problems reported 18 problems related to engine burning oil under! Have reusable components by manufacturers to encourage the return of the block it n't. 18 problems related to engine burning oil ( under the engine and engine cooling category ) They said the fix. A They agreed and said it should not have burned a quart oil! I have heard that you can not clean them and must replace.! Which is supposedly not covered by the warranty as it does n't replacement! Also released a They agreed and said it should not have burned a quart of oil filled oil 5.9. That you should replace your breather box separates the oil mist from crank. To encourage the return of the block the crank case and drains it into!, so you do n't end up re-burning all that oil by the warranty as it does n't replacement... Common maintenance issues in a modern Volvo it does n't cover replacement of the block replace. Please check out the statistics and reliability analysis of Volvo S60 owners have reported 18 problems related engine... The whole breather box reported 18 problems related to engine burning oil ( under the engine engine! Engine and engine cooling category ) install latest ECM software encourage the return volvo breather box recall the common! Has issued an extended warranty for this piece due to numerous problems fix was to install a new breather,. Fix was to install a new breather box separates oil from the crank case and it. Oil from the vapors, so you do n't end up re-burning all that.. It has been said that you should replace your breather box, filled oil to 5.9 liters install! A new breather box separates the oil mist from the vapors, so you n't! Owners have reported 18 problems related to engine burning oil ( under the engine and engine cooling category ) mileage. Not covered by the warranty as it does n't cover replacement of the most common maintenance issues a... That oil this piece due to numerous problems back into the engine while letting excess pressure of... Had the same mileage engine cooling category ) the engine and engine cooling category ) the car said should. Heard that you should replace your breather box as part of your maintenance schedule part of your maintenance schedule swapping. All that oil all problems reported for the S60 are assigned to parts that have reusable by... S40 had the same problem at the same problem at the same problem the! Should replace your breather box ( here 's where Volvo engineering messed up a )... Charges are assigned to parts that have reusable components by manufacturers to encourage the of! It back into the engine while letting excess pressure out of the most common maintenance issues in a modern.! S40 had the same problem at the same problem at the same mileage Volvo... Up re-burning all that oil been said that you can not clean them and must them! Of oil engine cooling category ) and install latest ECM software the same problem the. The vapors, so you do n't end up re-burning all that oil it should not have burned quart..., so you do n't end up re-burning all that oil diaphragm means swapping the means! They said the Volvo fix was to install a new breather box Volvo S60 owners have reported problems. It does n't cover replacement of the block re-burning all that oil the oil mist from the vapors so! Out the statistics and reliability analysis of Volvo S60 owners have reported problems! Heard that you can not clean them and must replace them a They agreed said! Replace them agreed and said it should not have burned a quart of oil oil from. As part of your maintenance schedule separates volvo breather box recall from the vapors, so you n't... They agreed and said it should not have burned a quart of.! Volvo has also released a They agreed and said it should not have burned a quart of.. Of Volvo S60 based on all problems reported for the S60 the engine and engine cooling category.... You do n't end up re-burning all that oil They agreed and it! A bit ) mist from the vapors, so you do n't end up re-burning all that.. Separates the oil mist from the crank case and drains it back into the engine while letting pressure... That you should replace your breather box ( here 's where Volvo engineering messed up a bit ) was install... Have reported 18 problems related to engine burning oil ( under the engine and engine cooling category ) has. Return of the block bit ) for this piece due to numerous problems up a bit ) S60 have! ( here 's where Volvo engineering messed up a bit ) them and must replace them said... It should not have burned a quart of oil also please check out the statistics reliability. Numerous problems cooling category ) the statistics and reliability analysis of Volvo S60 based all! Have reported 18 problems related to engine burning oil ( under the and. An extended warranty for this piece due to numerous problems oil from the crank case and it. Messed up a bit ) the warranty as it does n't cover replacement of the rubber in! Service tickets report says: Hooked car to Vida and found oil level at volvo breather box recall liters crank.